Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   KK007  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  GREAT WALL RESTAURANT Address  1545 W COURT ST
Owner or Operator   LIU, AI YIN City   KANKAKEE Zip Code   60901
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
X
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
X
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
  
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
X
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
 
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
  
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
X
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
X
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
X
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
X
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
X
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
X
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
X
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
X
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   chlorine 50-100 ppm                   Dishwasher Temperature   120-140 °F or label
Food Temperatures:   hot & sour soup 172, rice 179, chicken Tso's162, noodles 193, shrimp 166, Kung po chicken 176,seafood 199, crab 39, pudding 39, cheese 41, cole slaw 41, rice 190, fish 40
 
General Comments
 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  08/31/2010 Time In  1:45 PM Time Out  3:45 PM Sanitation Score  72 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  82  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   KK007  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  GREAT WALL RESTAURANT Address  1545 W COURT ST
Owner or Operator   LIU, AI YIN City   KANKAKEE Zip Code   60901
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*3  Observed the following potentially hazardous foods to be held at improper temperatures. 1.Raw chicken was found at 45F in walk-in cooler. 2. Beef was found at 46F. Provide for all cold potentially hazardous foods to be held at 41°F or below at all times except during necessary periods of preparation. 750.120 Immediate/Onsite
*7  Observed the following foods to be contaminated. Raw fish stored over BBQ chicken sauce. At all times, including while being stored, prepared, displayed, served, or transported, food shall be protected from potential contamination, including dust, insects, rodents, unclean equipment and utensils, unnecessary handling, coughs and sneezes, flooding, drainage, and overhead leakage or overhead drippage from condensation. 750.120 Next Inspection
*41  Observed the following chemical(s) to be improperly stored: Soy sauce was found stored by chemical spray bottles. Provide for all food, equipment, utensils, and single service articles to be stored either above or completely separate for all toxic chemicals. 750.830 Immediate/Onsite
8  Observed the following food products to be improperly stored. Raw chicken stored on the floor in kitchen. 2. Box's of pudding & mayo was stored on the floor in the dry storage room. Provide for all food products to be stored at least six inches off of the floor. 750.130 Next Inspection
9  Observed food service employees to be handling ready-to-eat foods without minimizing direct hand contact with the food product. Bowl was found in BBQ sauce. Food employees shall avoid direct contact with ready-to-eat food whenever possible and, to the extent possible, shall handle ready-to-eat food only with suitable utensils such as a deli tissue, spatulas, tongs, or single-use gloves. 750.280 Next Inspection
10  Observed the following utensil(s) to be improperly stored. Handle found in sugar and flour. Provide for all utensils to be stored in one of the following manners: 1) Clean and dry 2) In the food product with the handle up and out of the food product 3) In a dipper well, using potable water 4) Malt collars and frozen dessert utensils either clean and dry or ina dipper well. 750.280 Next Inspection
14  Observed the following improper food contact surfaces. There is a wooden shelf that needs to be painted and sealed in the dry storage shelf is where spices are kept. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbant, corrosive resistant, and light colored Next Inspection
15  Observed the following improper non-food contact surfaces. 1. Paint & seal dry storage shelf. 2. Bare wood is showing in back dry storage area. This is a repeat violation. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbant, corrosive resistant, and light colored. 750.690 Next Inspection
22  Observed the following food contact surfaces to be unclean. 1. Interior of the ice machine has mold growth on it. 2.Ground chicken slicer has food debris on it. Clean and maintain. 750.800 Next Inspection
23  Observed the following contact surfaces to be unclean. 1. Chest freezer has ice built up in it. 2. Toilet seat had debris on it. 3. Bottom of prep table has food debris on it. 4. Top of the sunfire oven has debris on it. Clean and maintain Next Inspection
32  Observed no soap and/or paper towels at the following handsink(s). There was no paper towels in the back employee restroom. Provide for all handsinks to have supply of soap and paper towels to assure that proper handwashing occurs. 750.1120 Next Inspection
34  Observed dumpster lids were left open. Keep shut at all times. 750.1140 Next Inspection
36  Observed the following floor areas to be unclean: 1. Floor under shelves in the walk-in freezer has food debris on it. 2. Floor in employee restroom has debris on it. Floor in soda box's room has debris on it. Provide for all flooring areas to be in a clean condition. Next Inspection
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  08/31/2010 Time In  1:45 PM Time Out  3:45 PM Sanitation Score  72 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  82  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   KK007  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  GREAT WALL RESTAURANT Address  1545 W COURT ST
Owner or Operator   LIU, AI YIN City   KANKAKEE Zip Code   60901
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  08/31/2010 Time In  1:45 PM Time Out  3:45 PM Sanitation Score  72 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  82